AuthorTopic: Changing door glass in a classc  (Read 1100 times)

0 Members and 1 Guest are viewing this topic.

Offline Reggieroo

  • Posts: 259
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Nr Pershore, Worcestershire
  • Referrals: 0
Changing door glass in a classc
« on: August 25, 2008, 14:02:58 »
Does anyone know how to change the front & rear door glass in a RRC?

I haven't done it before but would imagine it won't be to hard but some easy to follow instructions will make life easier.
1993 3.9 V8 Range Rover Classic
Audi 4.2 V8 S6 Quattro

For a taste of Ireland delivered direct to your door www.theirishshop.co.uk

My 4x4 websites.
www.offroad4x4s.com
www.offroadrangerovers.com
www.offroadlandrovers.com

Offline Skibum346

  • Posts: 1975
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • T. A. N. S. T. A. A. F. L.
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #1 on: August 26, 2008, 10:31:42 »
It's fairly straighforward matey... except for getting the window lifters out then back in again and they are just b****dy awkward due to the small access spaces left behind.

You'll probably need to replace the brassinated window holder (Sorry, don't know the correct title, but it grips the bottom of the window glass). It's a friction fit with some rubber gasket material and is pretty scary to fit... but some judicious use of a rubber mallet and a well supported window did the job.

It's also a good opportunity to replace the window channel gasket that the window sits in when wound up, and maybe the weather gasket around top of bottom half of door.

You might also want to invest in some spare door card fasteners (Red Spikes) as quite a few gave up trying to remove them.

Right... steps... as I remember them:
  • Remove door card
  • Remove mirror
  • Use gaffer tape to tape window in place, DON'T use sparingly!
  • Remove window lifter mechanism & motor (Put plenty of time aside for this!)
  • Remove weather gasket from top of bottom half of door
  • Unbolt window frame from door (4 bolts?)
  • Remove window frame & glass
  • Turn window frame upside down and remove glass, carefully!
  • Remove rotten window channel & replace with new
  • Replace window gasket in window frame
  • Reverse process

Good luck

Skibum
« Last Edit: August 26, 2008, 10:33:24 by Skibum346 »

Offline Reggieroo

  • Posts: 259
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Nr Pershore, Worcestershire
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #2 on: August 26, 2008, 11:03:11 »
Thanks for that skibum, its a big help.

It made me think about replacing the window channel gasket, any idea where to get it from?

Also do you know if you can just remove the frame & leave the window in place? The reason I ask is because the only reason I was removing the glass to tint it but if I just remove the frame I can tint the glass in the door.
1993 3.9 V8 Range Rover Classic
Audi 4.2 V8 S6 Quattro

For a taste of Ireland delivered direct to your door www.theirishshop.co.uk

My 4x4 websites.
www.offroad4x4s.com
www.offroadrangerovers.com
www.offroadlandrovers.com

Offline Skibum346

  • Posts: 1975
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • T. A. N. S. T. A. A. F. L.
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #3 on: August 27, 2008, 10:09:11 »
Reggie, I got my glass channel from a stealership, think they had to order it in but it's worth trying places like paddocks etc.

The whole window frame and glass lifts up out of the door (leaving the door looking a bit like an old series door without the door top on). This I assume would be perfect for tinting as it allows you access to the whole glass.

It's important to realise that the only thing holding the glass up is the window winder actuators (assuming you have electric windows!). Once that's off, the whole thing lifts out of the door and if you don;t have the all important gaffer tape in place... you'll here a small whistling sound (similar to the Wylie E Coyote falling sound... but much shorter!) followed by a bang/shatter!

I'd recommend getting hold of the necessary pages of a workshop book. The CD can be had from your local stealership for about £15.

Good luck

Skibum


Offline Reggieroo

  • Posts: 259
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Nr Pershore, Worcestershire
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #4 on: August 27, 2008, 10:26:32 »
Done the back ones yesterday, it was a bit of a nightmare as the window frames were rusty at the bottom so had to be treated first.

Also quarters in the back doors are a real [person of questionable parentage] to get back in , probably not to bad if I wasn't worried about damaging the tint which I did....... :evil: Now I've got the fronts to do, I didn't bother with the window channel gasket as it looked ok.
1993 3.9 V8 Range Rover Classic
Audi 4.2 V8 S6 Quattro

For a taste of Ireland delivered direct to your door www.theirishshop.co.uk

My 4x4 websites.
www.offroad4x4s.com
www.offroadrangerovers.com
www.offroadlandrovers.com

Offline Skibum346

  • Posts: 1975
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • T. A. N. S. T. A. A. F. L.
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #5 on: August 28, 2008, 13:31:32 »
Well done... I'd forgotten about the quarter lights.. not done those!

 :clap:

Offline GREENI

  • Posts: 538
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #6 on: August 28, 2008, 16:10:09 »
A good tip (I worked in the windscreen trade for years)...Get a marker pen, and draw around the bolts on the side of the frame before loosening, so you get the lines right when you put it back together !

Offline carracarra13

  • Posts: 581
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • just add mud lots of mud
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #7 on: September 04, 2008, 16:05:29 »
oh and be careful tinting frount side windows it is elegal as a polite police officer pointed out to me ([!Expletive Deleted!] if only I known befor gave me 7 days to ge it done (the nice officer)
v8 3.9 se discovery
pland mod lpg or hydrogen kit ?
allterains
twin battery, and water proofing engin and electrics
imverta

Offline jjsaul

  • Posts: 1534
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Leeds, West Yorks
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #8 on: September 04, 2008, 16:22:18 »
Window channels are about £17/ea from craddocks, a roll of the soft gasket stuff is also available from there.
James

...lovin dirty days out...

1983 OneTen V8 Station Wagon 3.5 (LPG)
1972 Range Rover V8
1992 Range Rover 4.6 (LPG)
1978 Range Rover Carmichael Commando 6x4
1972 Range Rover - Major project, FOR SALE
1976 Range Rover - Less of a project, FOR SALE
Previously: Range Rovers 1988, 1990 and others...
2005 Volvo V70 T5 SE (LPG) - daily driver


Offline Reggieroo

  • Posts: 259
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Nr Pershore, Worcestershire
  • Referrals: 0
Re: Changing door glass in a classc
« Reply #9 on: September 05, 2008, 21:46:18 »
oh and be careful tinting frount side windows it is elegal as a polite police officer pointed out to me ([!Expletive Deleted!] if only I known befor gave me 7 days to ge it done (the nice officer)

I know all about the crap tinting laws, I've had cars tinted for years...................just don't stop when the blue light comes on......... :lol:
1993 3.9 V8 Range Rover Classic
Audi 4.2 V8 S6 Quattro

For a taste of Ireland delivered direct to your door www.theirishshop.co.uk

My 4x4 websites.
www.offroad4x4s.com
www.offroadrangerovers.com
www.offroadlandrovers.com

 






SimplePortal 2.3.5 © 2008-2012, SimplePortal