Pages: [1]   Go Down

AuthorTopic: problem on the way home  (Read 3691 times)

0 Members and 2 Guests are viewing this topic.

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« on: November 30, 2005, 21:05:29 »
Hi Guys, Has anyone got a clue what could be wrong with my Disco??? I was driving home tonight when as i was trying to boot it up the hill it started to die on me??? Then when i got to the top it was fine again...plus has lost a bit of its kick when you open it right up, any ideas guys would be great :oops:  :oops:  :oops:
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
problem on the way home
« Reply #1 on: November 30, 2005, 21:13:00 »
what sort of disco is it?

TD5 or TDI ??
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
problem on the way home
« Reply #2 on: November 30, 2005, 21:15:46 »
lift pump on its way out,air filter choked & tryin to turn inside out,split intercooler hose,fuel filter choked
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

ChrisW

  • Guest
problem on the way home
« Reply #3 on: November 30, 2005, 21:31:58 »
What Mike said and check the spill lines as well - had a tiny split in one of mine which would suck air in when booting it and the engine would cough and stutter all over the place but soon as you drove it a bit more 'sedately' it was fine - check the braiding on the hoses for being soaked in diesel.
Logged

colintandy

  • Guest
power loss
« Reply #4 on: November 30, 2005, 23:09:26 »
have a good check on intercooler hoses its normally the one that you cant see very well  :shock: best to remove fully check /replace if bad also check that they not on to tight when put back as that can cause them to split under the jubilee clip and you wont notice till now so also check on the hoses where the clip has been positioned and make sure that the sit correctly over the rims of the connectors else will lose all preasure when under load, while you got off :D  may aswell check the fins on the turbo give all area a good clean pipes a good clean out also check front of intercooler if blocked with mud it wont work properly  :cry:
Logged

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #5 on: December 01, 2005, 11:15:08 »
Cheers Guys i will check it over at some point today ... :roll:  :wink:
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #6 on: December 06, 2005, 11:08:57 »
well guys its got worse... I have replaced the fuel filter put new glow plugs in checked all the hoses and the turbo is fine. :?  :? ..And know its stopped on me again as if the fuels not getting there??? It would only do 50 mph on the way home and every time I went near a hill slowed right up the picked up as if nothing was up then at the junction stopped dead :x  :x ...I started the disco and put my foot to the floor and it didn't rev over 4 grand..if it was a petrol I would of said not sparking or not enough fuel but diesels I have no idea,,,HELP???????
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline Damonski

  • Posts: 1081
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Cheshire :)
  • Referrals: 0
problem on the way home
« Reply #7 on: December 06, 2005, 11:27:19 »
Quote from: "Fingers Mclean"
It would only do 50 mph on the way home and every time I went near a hill slowed right up


Sounds normal for my Mpi.  Are you sure you dont have a mpi engine under there  :wink:   :lol:

Seriously tho, I think it could be the lift pump. I seem to recall other posts on other forums with similar symptons and everyone shouting about the lift pump.
Logged
--

Damian

Range Rover Classic 2.4TD  | Disco 300 Mpi | Citroen Xantia Activa
plus other rainy day projects....

Facebook Me

Offline iianorthants

  • Posts: 362
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #8 on: December 06, 2005, 11:38:25 »
sound like what was happening with my defender when lift pump went.
 to test on defender just need to carefully undo fuel filter and see if full to the brim ..... not full good chance of lift pump leaking, but not sure if the same on the disco
Logged

Offline petergalileo

  • Posts: 518
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #9 on: December 06, 2005, 15:09:36 »
Small air leak in the fuel supply would cause this too.  I dont reckon its anything major on the engine though as being a diesel and you havent said anything about large amounts of smoke which is normally a dead give away.

Peter
Logged
1996 300TDi Discovery ES - Java Black, Stainless Bullbar, Electric folding mirrors, TD5 Steering Wheel in Beige - Doesn't get muddy !

Freelander 1.8 Xi - LR Bodykit, Light Guards.

Offline Wanderer

  • Posts: 4846
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #10 on: December 06, 2005, 15:43:28 »
Often forgoten is the fuel sedimenter bowl under the o/s rear wheel arch on the inside of the chassis. It could be restricting fuel flow.

Is the tickover erratic while stationary?
If it is then it may be the springs in the injector pump. I had that earlier this year.
Logged
Ed
1993 200tdi Snorkly

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #11 on: December 07, 2005, 10:09:38 »
Will check out your ideas at some point in the next few days...Got a spare motor to use to get to work this week so no rush..Thanks again for the advice  :wink:
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline bambamjj

  • Posts: 362
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #12 on: December 07, 2005, 19:30:06 »
Was that you i saw heading North up the A3M yesterday by the rusty cutter then?

Jon
Logged
P reg 300 tdi Discovery, very slow, sluggish and standard but i am working on it.......

SOLD - Gutted
94 V8 Discovery 200 in Black
2" pro-comp lift
Spots
Diff Guards

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #13 on: December 09, 2005, 08:16:43 »
YES IT WAS  :lol:  :lol:  :lol: dont tell anyone though i got my mates wheels on it and it looks crap :oops:  :oops: still waiting for my tyres to turn up...should be here any day  :lol:  :lol:  :lol:
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline bambamjj

  • Posts: 362
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #14 on: December 09, 2005, 11:30:03 »
Very nice looking motor, i was heading in the opposite direction, but in a passat.  Puts mine to shame.
Logged
P reg 300 tdi Discovery, very slow, sluggish and standard but i am working on it.......

SOLD - Gutted
94 V8 Discovery 200 in Black
2" pro-comp lift
Spots
Diff Guards

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #15 on: December 09, 2005, 13:40:01 »
All done and working fine  :P  :P  :P  The rear filter thingy was blocked and had gunk and water in it some how!!! :lol:  :lol:  Glad its on the road again. Just waiting for my Silverstone extreme's to arrive from Bronco 4x4 so I can get them on my Disco and looking normal again (normal I mean nasty!!!) :twisted:  :twisted:  :twisted:  Instead of looking like a Tesco trolley  :wink:  :wink:
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)

Offline Wanderer

  • Posts: 4846
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #16 on: December 09, 2005, 14:39:47 »
Did you check the pipes on the sedimenter?
They sometimes corrode and allow air into the system.
Logged
Ed
1993 200tdi Snorkly

Offline Fingers Mclean

  • Posts: 365
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
problem on the way home
« Reply #17 on: December 09, 2005, 14:41:44 »
I cleaned the lot out blew a airline through the fuel line new filters etc so she's running sweet thanks  :wink:   :wink:  
Logged
CJ-7 5.9 AMC V8 Renegade Jeep (resto)
Freelander 3 door Serengeti 2.5 TD4
VERY Tricked up Jeep Wrangler
1200 Bandit
3 year old Son (Finlay Foo) ;-)
Pages: [1]   Go Up
 





SimplePortal 2.3.5 © 2008-2012, SimplePortal