Mud-club

Vehicle & Technical => Suzuki => Topic started by: sj-steward on October 29, 2008, 18:33:13

Title: please help my dingal bus run again!!!!!
Post by: sj-steward on October 29, 2008, 18:33:13

hi to all hope you can help Ive had problems with my SJ 413 since i brought it Saturday i brought a nother SJ413 last night for spears as mine was cutting out all the time so i swap ed the carb dizzy and coil over today and it run fine when standing still so i drove it about a mile and it cut out as if the revs was to low so i adjusted them up slightly then went out there this evening to see if it started OK from cold which it did and i noticed the rev counter was going mad??? i then switched on the lights and it rev ed to about 3-4000 revs on its own any ideas i am really gutted with it as i really want it running for woodlands sunday sorry for the long post hope someone can help  :(

Title: Re: please help my dingal bus run again!!!!!
Post by: generation-x on October 29, 2008, 19:14:05

hi m8
your carb is at fault im afraid to stop it revin wildly
if you look @ ur inlet maniold there shud be a green plug by the thermostat dis-conect it see if it helps

simon

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 29, 2008, 19:20:09

hi mate is that the auto choke ?? if so i have tried that with both carbs and it still does the same  :huh: i do have a Nikki carb but what throttle cable do i use and i can get any bouts to go trough to bout it down to the manifold

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 29, 2008, 19:21:06

sorry that was cant get any bouts trough

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 29, 2008, 19:52:21

 :oops:bolts i ment

Title: Re: please help my dingal bus run again!!!!!
Post by: generation-x on October 29, 2008, 20:24:24

hi m8
the green plug does work with the auto choke if you have removed it from the manifold and it still plays up then ur standard carb is goosed!!!!
as for a nikki they are a good choice of carb
you shud be able to modify the standard cable think you just have to file the nipple a bit to fit the nikki
as for bolts soz i cant remember so cant help on that

but i can say if you offroad fit the nikki so the window is @ the back not the front else it will most likely stall on hills

hope it helps
simon

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 29, 2008, 20:31:27

cheers but if i fit the window to the back the cable is way to short what other cable will fit both ends  :-k ?? thanks anyway

Title: Re: please help my dingal bus run again!!!!!
Post by: generation-x on October 30, 2008, 08:24:56

i no lots of people use bike brake cables for su fitment might be worth a go?

simon

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 30, 2008, 17:50:20

hi Simon the green plug you meant i have tried and so far it seems to be OK Hench i no i need the timing set up i thought you meant the black plug but yea thanks a lot with luck i think you might have done the trick cheers mate :D

Title: Re: please help my dingal bus run again!!!!!
Post by: generation-x on October 30, 2008, 18:32:29

hi m8 its only a short term solve you shud try to sort something out asap su wud be ur best bet

simon

Title: Re: please help my dingal bus run again!!!!!
Post by: sj-steward on October 30, 2008, 18:35:09

well after chrismas think ill go for the vitara engine as the sj has bit me in the back to much in just 5 days