Mud-club

Vehicle & Technical => Suzuki => Topic started by: wrecker on September 03, 2007, 18:13:26

Title: lot of travel with vit brakes
Post by: wrecker on September 03, 2007, 18:13:26

i put new pads,and shoes on my 94 vitara sport and they were fine,

went offroading yesterday and know the pedal goes a longway down,

it still stops ok but just dont fill right,its done this be4 and all i done was ajust the hand break,also the drums at the back,

would it be ok to do this again or is there a real prob,it seems every time i spend a day off roading,it does this,

i have no leakes,splits in pipes and cable looks fine so whats going on.

thanks for your time guys :D

Title: lot of travel with vit brakes
Post by: NEILH on September 03, 2007, 18:21:49

hi , have you tryed bleeding the brakes but if you did not undo any brake lines they should off been ok but try it.
     
      neil

Title: lot of travel with vit brakes
Post by: wrecker on September 03, 2007, 18:24:23

thanks for that mate,

dont want to sound dump bye asking but,,,

what is the best to do them mate :D

thanks again

Title: lot of travel with vit brakes
Post by: wheelspinner on September 03, 2007, 20:13:29

an eezi bleed is the easiest way......or a garage..

but you can do it with a mate, you need a piece of clear tube and a milk bottle.Make sure your fluid resevoir is full, wheel off, attach the clear tube to the brake nipple gently crack off the bleed nipple (this is the bit where it normally snaps off...probably best to WD40 it first) get your mate to give a couple of pushes on the brake pedal until you get a good air free flow of liquid from the tube into the milk bottle then tighten the nipple.keep filling resevoir with fresh fluid repeat all round....seem to remember its backs first then fronts on a vit.
Also depending how old the fluid is it could all need replacing.It get moisture in it.

Regards

Steve

Title: lot of travel with vit brakes
Post by: wrecker on September 03, 2007, 20:23:41

thanks for that mate,that is the way i normally do it just wasent sure if it was the right way.

thanks very much for your time,hope this works :?  :D

Title: lot of travel with vit brakes
Post by: generation-x on September 03, 2007, 21:31:16

mark did you clean out ur rear drums after u went playing?
id say they full of mud and not working right

simon

Title: lot of travel with vit brakes
Post by: wrecker on September 04, 2007, 18:23:25

hay simon

im just gonna go and have a look in a bit so ill post up what i find,

also as its my every day truck on the way home with the window open i can a rubbing noise comeing from the rear only when coming to a stop,

well wish me luck and ill post what i find :?  :?  :?  :?

mark

Title: lot of travel with vit brakes
Post by: generation-x on September 04, 2007, 19:36:03

well mark its been ages??

simon

Title: lot of travel with vit brakes
Post by: wrecker on September 04, 2007, 22:35:39

well its DONE :D  :D

its very strange tho,

had an air lock on right hand side,but have not undone any screws or any thing, :?

and it was coverd in mud so cleared that out,but right hand side still did not work,(drivers side)

so got it on ramps ticking over in 3rd to get wheels spinning then hit the peddel,nothing :shock:  :shock:

in the end it was the self ajusting spring and stop that was sticking out for some reason,so every time i braked the stop and spring would touch drum,and same time undo it self so no stopping power from that side at all,

all i done was changed the spring and its fine :roll:  :x

but one thing bothers me,why would it do that,its not been touched as far as i can see just moving out to rub the drum which is a long way to go,

any ideas chaps :?:  :?:  :?:

Title: lot of travel with vit brakes
Post by: generation-x on September 05, 2007, 10:13:32

mark
the adjuster wud come lose if the pads were jammed into ur drum i wud of thought
best to fit a rear disc conversion and be done with it

glad u got it sorted thou

simon

Title: lot of travel with vit brakes
Post by: wrecker on September 05, 2007, 19:56:07

disc,uuum

so simon,fancy telling me more info on doing this, :D

didnt know you could :lol:

mark

Title: lot of travel with vit brakes
Post by: generation-x on September 05, 2007, 21:31:29

yes m8
you need to get in touch with rob toft on muddyzook.com or pm him off my site
he does a rear disc conversion for the vitara with a hand brake conversion for about £100 ish

simon

Title: lot of travel with vit brakes
Post by: wrecker on September 06, 2007, 22:36:51

thanks for that matey,

i have pm him,

thanks again

mark :)

Title: lot of travel with vit brakes
Post by: generation-x on September 07, 2007, 00:13:18

Quote from: "wrecker"

thanks for that matey,

i have pm him,

thanks again

mark :)

from where my site?

simon