Mud-club

Vehicle & Technical => Suzuki => Topic started by: eugene on November 30, 2009, 20:11:27

Title: sj wont run
Post by: eugene on November 30, 2009, 20:11:27

hi my wife a a sj410 for offroading the thing is i cant get it to run properly it has a speed boat petrol tank in it and the standard one removed the petrol return pipe is blocked of ive put new dizzy cap rotor arm plugs and leads on it and new air filter it start straight away and when choke is fully out revs loads screams infact drop the choke off to half way and try to rev then it dyes any advice welcome its doing my head in
thanks
eugene

Title: Re: sj wont run
Post by: 4xmike on December 01, 2009, 15:55:10

Hi
Not sure if this is it but there is a pump on the bottom of the carb that adds fuel when you rev it,if used off road the pump arm sticks on the shaft & causes poor runnning when you rev it,its worth a look ,just see if the arm moves up & down easily
4xmike

Title: Re: sj wont run
Post by: generation-x on December 01, 2009, 18:23:39

hi can i ask why you have blocked the return pipe?

id quess its over fueling now
might be worth unblockin the return into a seperate can and see wot it runs like if it does run


Simon

Title: Re: sj wont run
Post by: eugene on December 01, 2009, 20:00:42

thanks 4xmike will try that at the week end and simon it was already blocked of because it have a speed boat take like a banger tank in it have tryed what you said but still the same

Title: Re: sj wont run
Post by: 4xmike on December 01, 2009, 20:21:21

Hi
me again !!
I had a 410 that I bought & it was fitted with a boat tank when I got it & it only had a feed to the carb & no return & that alway ran ok,so I dont think its that
4xmike

Title: Re: sj wont run
Post by: eugene on December 02, 2009, 18:25:03

cheers 4xmike il keep playing

Title: Re: sj wont run
Post by: generation-x on December 02, 2009, 20:13:53

hi m8
reading your 1st post you are sayin it will run with full choke? but wont even if only half closed?

Simon

Title: Re: sj wont run
Post by: eugene on December 02, 2009, 20:40:31

on half choke it runs then when you put foot down it dies

Title: Re: sj wont run
Post by: generation-x on December 02, 2009, 20:44:06

sounds like the jet needle is chuffed m8y have you tried another carb on the engine?

simon

Title: Re: sj wont run
Post by: digger on December 02, 2009, 20:49:36

SET FIRE TO IT YOU OLD CU*T :grin:

Title: Re: sj wont run
Post by: generation-x on December 02, 2009, 20:51:17

also does it have a snorkle fitted ? if so wot sort? as also sounds like to much air gettin into the carb and killing it

Simon

Title: Re: sj wont run
Post by: eugene on December 03, 2009, 19:21:34

thanks scott for the input and it has a snorkel on it well a henry hovver hose that was on it when i got it il try blocking it off

Title: Re: sj wont run
Post by: sam yelland on December 14, 2009, 13:54:18

let me know how that carb i gave you goes

Title: Re: sj wont run
Post by: eugene on December 16, 2009, 20:07:31

will do mate  :D