Mud-club

Vehicle & Technical => Discovery => Topic started by: bilge rat on October 20, 2008, 19:40:13

Title: 200 heater motor
Post by: bilge rat on October 20, 2008, 19:40:13

think it must be seized. can i get at it . cant seem to find it . different to the 300. can someone tell me iff i can get at it . alan....

Title: Re: 200 heater motor
Post by: eugene on October 20, 2008, 19:57:18

i had to take the dash out a pig of a job the heater and fan bolted to the bulkhead had a rat jam in it whikle i was doing it up lots of black smoke a nd a burn rat but i couldnt see any other way of doing it so goodluck anyway :D

Title: Re: 200 heater motor
Post by: bilge rat on October 20, 2008, 20:23:26

you dont think theres any way of getting any thing on it to try to spin it up . im sure its just seized . been stood abot6 mths. thanks. alan

Title: Re: 200 heater motor
Post by: crazymac on October 21, 2008, 19:44:32

Chances are it has burnt out :-k

And the only way to get to it is remove the whole bulkhead :'(

Its a lot of work but not difficult in its own right!

Centre console, steering wheel, top binacle then about 8 other fixings if I remember right? then you could do with another person to help you lit it out as its a bit floppy :roll:

Title: Re: 200 heater motor
Post by: wrecker on October 21, 2008, 21:23:02

i done this a few weeks back mate,

and there is no way to get at it with out gettin the dash out,

first pic is dash out,that black box in the middel,thats where the motor is at

(http://i249.photobucket.com/albums/gg203/wreckermk2/20-07-08_1108_ds.jpg)

2nd pic is with it out

(http://i249.photobucket.com/albums/gg203/wreckermk2/20-07-08_1205_ds.jpg)

and this is what you have to split in half to get at the motor,make sure you have a helper here,it makes the job a lot quicker

(http://i249.photobucket.com/albums/gg203/wreckermk2/20-07-08_1206_ds.jpg)
if you look left bottom,that the wires for the motor,and some of the motor,

hope this is of any help to you :D

Title: Re: 200 heater motor
Post by: bilge rat on October 22, 2008, 09:08:18

thanks for that . its one of them still unsure what to do with the truck ?. dont stand me at much but keep doing little bits to it.. thanks again . alan...

Title: Re: 200 heater motor
Post by: bilge rat on October 23, 2008, 22:01:29

got the lousy thing out and it had burnt out . got it running again but not for long . any one know of a cheap heater motor .. thanks alan...

Title: Re: 200 heater motor
Post by: Dr Neil on October 24, 2008, 20:16:55

Paddocks sell them £64.59 new!!