Vehicle & Technical > Defender

Fuel tank sender unit wiring on 90 2.5NA

(1/2) > >>

Kenny:
Fitted a new fuel tank the other week and connected the sender up as the old one was but it did not work correctly. I then played around with the wires and got it reading the fuel level, well so I thought until it started to get low on fuel.

Now I am just above reserve the gauge goes up and down like a Yo Yo when I change gear, go up and down hill etc. Most worrying though is the lack of the low fuel warning light. I would expect that if going around a corner or up a hill etc. and the gauge moves down below the reserve warning the low fuel light would come on.

This was working before I did the job and does make an effort to come on every now and again which indicates to me that the buld it OK.

Does anyone know the correct wiring for the sender unit.

There are three wires front to back.

Cheers

Damian

Les Henson:



Les.

gnasha:
if its a diff type to what les has put up let me no as mine diff and will take a pic 4 ya and see if mine is same

Kenny:
Thats what I thought it was - tried that and it increased a little bit from the bottom, turned the ignition on and it went flat.

I wonder if the sender could be faulty

Damian

Les Henson:
Try adding a temporary earth from the tank to the chassis. Sender units quite often suffer from earth connection problems.


Les.

Navigation

[0] Message Index

[#] Next page