Vehicle & Technical > Defender

Turbo Oil Seal Gone?

(1/2) > >>

Mark_Solesbury:
Morning...

Ive noticed that over the past few months my 300tdi has started to smoke more than it used to. Black smoke normally when its under load.

Ive taken all the pipes off from the intercooler/airfilter/turbo and there is some oil in them all..

Now, ive never taken them off in the year ive had it so i dont know how long its been there.

Is this normal? It not dripping wet, but if you put your hand inside your hands get black...

Ive got some pics, but at the mo im outside. Ill upload them when i get back in.

Im going to take the intercooler off in a bit and see how bad it is in there..

My plan is to take the pipes inside and clean them up, leave it a week and see how bad it is again.


Edit : Pics

Hoses


From Intercooler to Turbo


Pipe from Intercooler end of Intercooler to Turbo


From Air Filter to Turbo


Inside Intercooler Top


Turbo



Originals are here, and can be viewed at full res by link under photo.

Rasbo:
could well be, but i'd be inclined to whip off the egr blanking plate first, stick my fingers down it and see if theres any oil there as it could just be a head gasket prob. failing that then either your correct and the seals need replacing or the engines breathing (very unlikly on a 300)

Mark_Solesbury:
Its dry inside the manifold, felt though the egr hole :)

So it looks like the turbo is on its way out then?

Mark_Solesbury:

Upon further investigation, it seems that oil has gone from the the oil cooler part breather pipe, down into the big pipe from the back of the air filter and though the turbo and intercooler that way.

Any ideas?

Xtremeteam:
they all do that,

wouldnt worry about it

Navigation

[0] Message Index

[#] Next page