Vehicle & Technical > Discovery
sluggish 200tdi
Little Chris:
Is there any chance that in the repair work some debris could have blocked the injectors?
If so i do know a very good company that recondition them.
extreme90:
--- Quote from: "lroh96" ---Is there any chance that in the repair work some debris could have blocked the injectors?
If so i do know a very good company that recondition them.
--- End quote ---
no, its just the blinning shaft sized good :cry: :cry:
it still refuses to play
still, can play with it tomorrow in the light which always helps
dan
solihull-mick:
Ive had this problem a few times now, when the diaphram wont lift out,its the small rod that touches the ramp on the diaphram shaft thats seized, if you remove the throttle lever, but leave the spring on the pump, there is an alen key bung, remove this and you can get to the other side of this rod, lots of wd and a bit of work they free up sweet, when the rod sezies they cause a real loack of power, ive been fitting a small filter on the pipe from the turbo to the top of the injection pump, to try and stop water and crud entering the fuel pump, also the breather on the rear of the pump can be extended, its a little round rubber thing with a small tube off it,
Ive worked with bosch pumps for many years know and this did stump me the first time i came across it, had it a few weeks ago on chris w`s disco rebuild, did the normal pump trick, instant no power!, rod seized, hope this makes sense :D
davidlandy:
when the little rod seizes , does it do this in a particular position, or could it be any position?
I ask this because I reckon that mine may be partially seized as it over fuels all the time on low revs prior to the turbo spooling up and I have tried most things to stop it and i cant get the balance right - theres always smoke no matter what the power setting
Range Rover Blues:
Interesting that, Julies has always smoked, though it goes like a stabbed rat. Even now I've rebuilt the head, it runs quieter, uses a bit less fuel and goes like stink it smokes.
Thing is I didn't do the pump tweak and I don't know who did, it was a quick car when my mate bought it. It'll give Blue a run for it's money and that's a 3.9V8.
Navigation
[0] Message Index
[#] Next page
[*] Previous page
Go to full version